Relax just be aware
RudiGreyling said:
I?m confused and do not have any experience to draw from so I open up the question.
How real is carb icing on RV?s specifically and how avoidable is it?
Thank you, Kind Regards Rudi
It is VERY real and very avoidable. I suggest you Google carb ice and read all you can to brush up on the cause, conditions and defenses. Also check this forum, there are a few good threads on the topic. AOPA has a ice write up and there is a ton of info on the web. Here is one:
http://www.vansairforce.com/community/showthread.php?t=8702&highlight=carb
First if you have this level of attention to avoiding carb ice when you fly as your post indicates, you want to understand, than you chance of carb ice is NIL. Most carb ice accidents are from pure pilot complacency, lack of training or poor procedures or no clue.
It's true RV's are less likely to get carb ice because they have Lyc's which in general with their heated sump and warm carb are more resistant (NOT immune) to carb ice. Add the fact our cowls are tight and the exhaust pipes go aft near the carb, good for carb ice RESISTANCE, not good for vapor lock, but that is another issue. Note, I said resistance to carb ice. RV's VAN AND DO AND HAVE HAD CARB ICE incidencies. Engines like the Continental O-470 in the C-182 are very prone to Carb ice due to the fact the carb and induction tubes are not on the hot sump. The good news it is not common, but there are things you can do to make the chance of it happening to you basiclly zero.
The down side of RV's is they tend to have poor basic carb heat design. In part that is because there are so few carb ice accident with RV's, so even the poor stock carb heat has worked. That does not mean it is good. The original stock Van's carb heat is just open the filtered air box (FAB) into the cowl area, in theory to draw warm air from the cowl. That may be fine if you are in mild conditions and use it early or proactively as a preventive measure. Also later the optional "stove pipe" Van now sells is better, but still marginal and a small improvement in my opinion. Most have gone to a dedicated heat muff for carb heat. You can find them at Spruce Air or Wicks (see thread above). If I lived and only flew in SW Arizona I might not worry about it. However for a IFR bird or a plane I planned on doing X-C I would install a more substantial Carb heat muff than what Van offers in their catalog. It may be overkill?
Last line of defense is a CAT or Ice Man probe. Carb air temp (CAT) can improve you awareness of potential for carb ice. The "Ice Man" probe is a optical device that actually accumulates ice in the carb throat and gives a aural and visual warning. It does not measure temp it "sees" the ice. They tend to be very sensitive and can go off all the time, in even very mild conditons, but it will let you know early, way before ice accumulates on the carb throat or butter fly. Some find it annoying and others like it. There is CAB ICE where the engine chokes off and a light internal frost of the carb which comes and goes. The ICE MAN is super sensitive but the best device if ice detection. I am not recommending it, but do value the CAT gage. It does not tell you if you have carb ice but tells you if your carb air temp is in a critical range. What many RV'ers find is the air in the carb is often very warm for the reasons I mentioned at the beginning (RV's are carb ice resistant but not immune).
Carb ice is a rare problem, but can be deadly. If you're going to do idle descents from 8,000 feet, on a humid day with ambient temps in the critical range, expect to get carb ice. If idle descents are your thing, you may have a (bad) surprise someday. Even if you use Carb heat with Van's marginal capacity it may not be enough at idle power.
I never use idle power for long descents and use carb heat if there's ANY DOUBT that carb ice conditions might be more likely. When I plan a decent I start down earlier and keep the power up (21" of map). You can put a carb ice chart on your panel that gives you temp verses relative humidity and carb ice severity. Here is a typical chart (click to enlarge):
I only got carb ice on my RV-4 on taxi out, that I was aware of. I say aware of because you would be surprised how "frosty" your carb gets sometimes. However there is a big differnce in engine choking ice build up on the carb venturi and butterfly and a light frosting. When I flew in the humid area Northwest, doing run-ups, I noticed after applying carb ice engine RPM picked up after 10-20 seconds, even with a constant speed prop since it was below the governor range. When the carb heat was turned off the RPM was higher than I started with. Hummmm. People don't leave the carb heat on long enough to do any good. Same in flight, KNOW WHAT TO LOOK FOR. You don't just pull the carb ice out and shove it back in. You pull it out and note the MAP drop (constant speed) or RPM drop (fixed prop) and WAIT. Look for either MAP or RPM to go back up. Same on the ground, look for the effect of carb heat just as you apply it, after it has been on for awhile and after you turn it off. You don't necessarily want to fly around with carb heat on all the time, especially take off. If you do fly with carb heat on continuously as a preventive measure, don't forget to re-lean, since you are now richer with the warm air. Also after you turn carb heat off, you may need to re-lean.
I used the Piper method of carb heat verses the Cessna method. The Cessna method called for carb heat ON for the entire approach and landing. The piper method is more of a check, turn it On than Off, when arriving on initial approach / pattern, i.e. check for carb ice affects. Depending on conditions (dry/hot) that could be just a quick "does it work" to a 2 minute leave it on the whole time (wet/30-70F). You have a OAT gage right? Well if you see water, like rain, mist, fog or standing water or snow on the ramp, that is visable mosture and high humidity.
Rudi, relax but from now on when you listen to ATIS and you hear the temp dew point spread is 0, 1, 2, 3 or even 5 to 10 degrees (F), consider carb ice. If you live in Phoenix, carb ice is not as likely as Seattle. Remember the idea is prevent it. If you get carb ice and the engine is choked off there is no more heat to melt it off after the fact. It's a real issue and I think it contributes to about 17 accidents a year, but this is totally avoidable with some thinking on the pilots part. Add a line in your check list, Got Carb ICE?
Just remember keep your engine HOT with some power you will avoid all but the worst conditions. Also consider a carb temp gage.
Bottom line the RV is NO MORE likely to get carb ice than any other carb'ed Cessna or Piper and may be even less; however if you get severe carb ice the RV may have less carb heat to get out of trouble than a Piper or Cessna.